dead battery, now the codes!

Discussion in 'New Member Introduction' started by RJ90703, May 14, 2019 at 7:22 PM.

  1. RJ90703

    RJ90703 New Member

    1
    1
    0
    Hi all! I recently had a bike shipped to me from the east coast to Cali..made it down here after 7 days.. The bike was not placed in transport mode and by the time it got here, its completely dead. The bike was error free and running without any issues, but now after I tried to jump the dead bat and placed in on tender overnight, the bike starts but a few codes were popping up! cleared some of them and hasnt returned.. the only ones left are P1511 & P2176. The bike appears to be on limp mode..it starts, but with very little to no throttle response. & also noticed the idle is a bit rough... I tried clearing the codes but I couldn't.. If anyone can help, I'd really appreciate it.. btw, the bike is a 17' fxdls with the 117se kit. Thank you in advance!

    RJ
     
  2. Joyflyin

    Joyflyin Experienced Member Staff Member Moderator

    5,984
    133
    240
    Welcome aboard, glad to have you here. There are a bunch of knowledgeable folks here and I'm sure one of them will be along shortly that can help you out!
     
  3. Harttoo

    Harttoo Well-Known Member

    2,725
    103
    254
    Welcome from Wisconsin. P1511 is EFI power management mode.This has to do with the throttle actuator control.Did You do anything with the right hand control assembly? Or did it get wet?Who knows what low or no voltage can do? P2176 is EFI closed position not learned, which also points to the throttle control actuator.Did someone pull on the throttle grip so hard that it pulled away from the sprocket that it turns? That would explain the weird idle.
     
  4. Jeff Klarich

    Jeff Klarich Experienced Member Contributor

    5,369
    183
    633
    1. Harley Fault Codes 2004-2015
    2. Below is a list of comprehensive list of diagnostic codes that you may come across on your Harley-Davidson.How to Read Error Codes
      1. With the ignition in the off position, press and hold the trip meter button, and turn the ginition swith to the on position.
      2. Release the button. Your speedo indicators should illuminate and the needle should do a full sweep.
      3. “diag” will appear on the odometer screen. Press the trip button once.
      4. “PSSPt” is now displayed. Each of the letters represents a different area.
        • P = ECM / ICM (Engine / Ignition Control Module)

        • S = TSM / TSSM (Turn Signal / Turn Signal Security Module)

        • SP = Speedometer

        • t = Tachometer
      5. You can highlight each area by pressing the button. Once the area you wish to select is highlighted, press and hold the button for 5 seconds.
      6. If there are any codes, you will be able to go through them one at a time by pressing the button. Once you have them recorded, they can be cleared by holding the button for more than 5 seconds. Once “clear” is on the screen, press the button once more.
      7. To exit the Diagnostic Mode, turn the ignition switch off.


      Harley Sensor and Motor Codes
      POO51 Heater Control Circuit 02 Sensor Low
      PO106 Map Sensor Rate of Range Error
      P0107 Map Sensor Failed Open/Low
      P0108 Map Sensor Failed High
      P0112 IAT Sensor Voltage Low
      P0113 IAT Sensor Voltage Open / High
      P0117 ET Sensor Voltage Low
      P0118 ET Sensor Voltage Open / High
      P0120 TPS1 Range Error TPS
      P0122 TPS1 Low TPS
      P0123 TPS1 High / Open TPS
      P0131 Front 02 Sensor Low (lean)
      P0132 Front 02 Sensor High (rich)
      P0134 Front 02 Sensor Open / Not Responding
      P0151 Rear 02 Sensor Low (lean)
      P0152 Rear 02 Sensor High (rich)
      P0154 Rear 02 Sensor Open / Not Responding
      P0220 TPS2 Range Error
      P0222 TPS2 Low TPS
      P0223 TPS2 High/Open
      P0261 Front Injector Open/Low
      P0262 Front Injector High
      P0263 Rear Injector Open/Low
      P0264 Rear Injector High (CAN-Bus)
      P0264 Rear Injector Open/Low
      P0265 Rear Injector High
      P0371 Crank Position Sensor, Too Many Pulses
      P0372 Crank Position Sensor, Too Few Pulses
      P0373 CKP Sensor Intermittent
      P0374 CKP Sensor Not Detected
      P0444 Purge Solenoid (Evap. Canister) Open/Low
      P0445 Purge Solenoid (Evap. Canister) High
      P0501 VSS Low
      P0502 VSS High/Open (Can-Bus)
      P0502 VSS Speed Failed Low
      P0503 VSS Speed Failed High
      P0505 Loss of Idle Speed Control
      P0506 Idle Speed Control RPM Too Low
      P0507 Idle Air Control System RPM Higher Than Expected
      P0562 Battery Voltage Low
      P0563 Battery Voltage High
      P0572 Brake Switch Low
      P0577 Cruise Control Input High
      P0602 Calibration Memory Error
      P0603 ECM EEPROM Failure
      P0604 RAM Failure
      P0605 ECM Flash Error
      P0607 Converter Error
      P0641 5V+Vref 1 Out of Range
      P0651 5V+Vref 2 Out of Range
      P0661 Intake Solenoid Low/Open
      P0662 Intake Solenoid High/Shorted
      P1001 System Relay Coil Open/Low
      P1002 System Relay Coil High/Shorted
      P1003 System Relay Contacts Open
      P1004 System Relay Contacts Closed
      P1009 Incorrect Password
      P1010 Missing Password
      P1270 TGS Validation Error
      P1351 Front Ignition Open/Low
      P1352 Front Ignition Coil High/Shorted
      P1353 Front Cylinder No Combustion
      P1354 Rear Ignition Coil Open/Low
      P1355 Rear Ignition Coil High/Shorted
      P1356 Rear Cylinder No Combustion
      P1357 Front Intermittent Secondary Combustion
      P1358 Rear Intermittent Secondary Combustion
      P1475 Exhaust Actuation Position Error
      P1477 Exhaust Actuator Open/Low
      P1478 Exhaust Actuator Shorted/High
      P1501 Jiffy Stand Sensor Low
      P1502 Jiffy Stand Sensor High
      P1510 EFI Limited Performance Mode (TBW)
      P1511 EFI Power Management Mode
      P1512 EFI Forced Idle Mode
      P1514 Air Flow Fault (TBW)
      P1600 EFI Module Processor Internal Error
      P1632 Odometer Learned Up
      P2100 EFI TCA Motor Circuit Open (TBW)
      P2101 EFI TCA Motor Circuit Range/Performance
      P2102 EFI TCA Motor Circuit Low
      P2103 EFI TCA Motor Circuit High
      P2105 EFI Forced Engine Shutdown
      P2107 EFI Module Control Processor Internal Fault
      P2119 EFI Motor Throttle Body Range Performance (TBW)
      P2122 TGS1 Low/Open
      P2123 TGS1 High
      P2127 TGS2 Low/Open
      P2128 TGS2 High
      P2135 TPS Voltage Correlation Error
      P2138 TGS Voltage Correlation Error
      P2176 EFI Closed Postion Not Learned
      P2300 Front Ignition Coil Driver Low/Open
      P2301 Front Ignition Coil Driver High/Shortened
      P2303 Rear Ignition Coil Driver Low/Open
      P2304 Rear Ignition Coil Driver High/Shortened
      Harley ABS and Power Circuit Codes
      C0562 Device Voltage Low
      C0563 Device Voltage High
      C1014 ECU Internal Fault ABS
      C1017 Pump Motor Power Circuit Fault
      C1018 Pump Motor Ground High Resistance Fault
      C1021 Front Wheel Speed Sensor Equals Zero
      C1023 Rear Wheel Speed Sensor Equals Zero
      C1025 Front Wheel Speed Signal Intermittent
      C1027 Front Wheel Speed Frequency Out Of Range
      C1032 Front Wheel Speed Sensor Open or Shorted
      C1034 Rear Wheel Speed Sensor Open or Shorted
      C1041 Rear Actuator Circuit Low/Open
      C1042 Front Actuator Circuit Open
      C1043 Pump Motor Stalled
      C1044 Rear Actuator Circuit Open
      C1052 Rear Actuator Circuit High
      C1055 ABS ECU Internal Fault
      C1066 ECU Internal Fault
      C1094 Front Brake Switch Always On
      C1095 Front Brake Switch Open
      C1102 Rear Actuator Motor Stalled
      C1118 ECU Internal Fault
      C1121 ECU Internal Fault
      C1151 Front Wheel Release Too Long
      C1153 Rear Wheel Release Too Long
      C1158 Calibration Programming Required
      C1178 No VIN Received From ECM
      C1184 VIN Does Not Match ABS ECU Calibration
      C1192 Front Actuator Circuit High
      C1193 Front Actuator Motor Stalled/td>
      C1206 Front Wheel Speed Sensor Frequency Out of Range
      C1207 Rear Wheel Speed Signal Intermittent
      C1208 Rear Wheel Speed Sensor Frequency Out of Range
      C1212 Front or Rear Brake not Applied With Decel
      C1214 Rear Brake Switch Always On
      C1216 Rear Brake Switch Open
      C1222 ABS Voltage Low Terminal 11
      C1223 ABS Voltage Low Terminal 20
      C1224 Front Actuator Power Shorted High
      C1225 Rear Actuator Power Shorted High
      C1561 Front Apply Solenoid Circuit Open or High
      C1562 Front Apply Solenoid Circuit Shorted Low
      C1563 Front Solenoid Circuit Shorted High
      C1564 Front Release Solenoid Circuit Open or High
      C1565 Front Release Solenoid Circuit Shorted Low
      C1567 Rear Apply Solenoid Circuit Open or High
      C1568 Rear Apply Solenoid Circuit Shorted Low
      C1571 Rear Solenoid Circuit Shorted High
      C1572 Rear Release Solenoid Circuit Open or High Resistance
      C1573 Rear Realease Solenoid Circuit Shorted Low


      Harley Battery, Ignition, Lighting Codes
      B0563 Battery Voltage High TSM / TSSM
      B1004 Fuel Level Sending Unit Low Instruments
      B1005 Fuel Level Sending Unit High / Open
      B1006 Accessory Line Overvoltage
      B1007 Ignition Line Overvoltage Instruments
      B1008 Reset Switch Closed Instruments
      B1101 LHCM Turn Signal Bulb Out
      B1103 LHCM Internal Fault
      B1121 Left Turn Output Fault TSM / TSSM
      B1122 Right Turn Output Fault TSM / TSSM
      B1123 Left Turn Output Short to Ground TSM/TSSM
      B1124 Right Turn Output Short to Ground TSM/TSSM
      B1125 Left Turn Output Short to Battery TSM/TSSM
      B1126 Right Turn Output Short to Battery TSM/TSSM
      B1131 Alarm Output Low TSSM
      B1132 Alarm Output High TSSM
      B1134 Starter Output High TSM/TSSM
      B1135 Accelerometer Fault TSM/TSSM
      B1136 Accelerometer Tip Test Error TSSM
      B1141 Ignition Switch Open / Low TSSM
      B1142 Smart Security System Internal Fault TSSM
      B1143 Security Antenna Short To Ground TSSM
      B1144 Security Antenna Short To Battery TSSM
      B1145 Security Antenna Open TSSM
      B1151 (Sidecar) BAS Low TSM/TSSM
      B1151 RHCM Turn Signal Bulb Out
      B1152 (Sidecar) BAS High TSM/TSSM
      B1153 (Sidecar) BAS Out Of Range TSM/TSSM
      B1153 RHCM Internal Fault
      B1154 Clutch Switch Input Short To Ground
      B1155 Neutral Switch Input Short To Battery
      B1200 Instrument Internal Fault
      B1210 Fuel Sender Shorted Low / Fuel Gauge Circuit
      B1211 Fuel Sender Shorted High / Open
      B2102 System Power Output Shorted High
      B2103 System Power Output Shorted Low
      B2104 System Power Output Overloaded
      B2107 Front Position / Running Power Output Shorted High
      B2108 Front Position / Running Power Output Shorted Low
      B2109 Front Position / Running Power Output Overloaded
      B2112 Accessory Output Shorted High
      B2113 Accessory Output Shorted Low
      B2114 Accessory Output Overloaded
      B2116 Fuel Pump Output Open
      B2117 Fuel Pump Output Shorted High
      B2118 Fuel Pump Output Shorted Low
      B2119 Fuel Pump Output Overloaded
      B2121 Starter Output Open/BCM Malfunction
      B2122 Starter Output Shorted High
      B2123 Starter Output Shorted Low
      B2124 Starter Output Overloaded
      B2126 Horn Output Open
      B2127 Horn Output Shorted High
      B2128 Horn Output Shorted Low
      B2129 Horn Output Overloaded
      B2131 High Beam Output Open
      B2132 High Beam Output Shorted High
      B2133 High Beam Output Shorted Low
      B2134 High Beam Output Overloaded
      B2136 Low Beam Output Open
      B2137 Low Beam Output Shorted High
      B2138 Low Beam Output Shorted Low
      B2139 Low Beam Output Overloaded
      B2141 Left Front Turn Signal Output Open
      B2143 Left Front Turn Signal Output Shorted Low
      B2144 Left Front Turn Signal Output Overloaded
      B2146 Right Front Turn Signal Output Open
      B2148 Right Front Turn Signal Output Shorted Low
      B2149 Right Front Turn Signal Output Overloaded
      B2151 Left Rear Turn Signal Output Open
      B2153 Left Rear Turn Signal Output Shorted Low
      B2154 Left Rear Turn Signal Output Overloaded
      B2156 Right Rear Turn Signal Output Open
      B2158 Right Rear Turn Signal Output Shorted Low
      B2159 Right Rear Turn Signal Output Overloaded
      B2161 Brake Lamp Output Open
      B2163 Brake Lamp Output Shorted Low
      B2164 Brake Lamp Output Overloaded
      B2166 Running Lights Output Open
      B2168 Running Lights Output Shorted High
      B2169 Running Lights Output Shorted Low
      B2172 Security Siren Output Shorted High
      B2173 Security Siren Output Shorted Low
      B2176 Security Antenna Output Open
      B2177 Security Antenna Output Shorted High
      B2178 Security Antenna Output Shorted Low
      B2203 Ignition Switch Input Shorted Low
      B2206 Engine Stop Switch Input Open/Shorted High
      B2208 Engine Stop Switch Input Shorted Low
      B2218 Neutral Switch Shorted Low
      B2223 Rear Brake Switch Shorted Low
      B2250 Clutch Switch Stuck
      B2251 Horn Switch Stuck
      B2252 High Beam Switch Stuck
      B2253 Low Beam Switch Stuck
      B2254 Left Turn Switch Stuck
      B2255 Trip Switch Stuck
      B2260 Start Switch Stuck
      B2261 Right Turn Switch Stuck
      B2262 Front Brake Switch Stuck
      B2263 Hazard Switch Stuck
      B2270 BCM Internal Fault
      B2271 BCM Low Voltage
      B2272 BCM or Speedometer Voltage High
      B2274 Constant Battery Line Fault

      Harley CAN Bus Codes
      U0001 CAN bus Fault
      U0011 CAN bus Low Shorted / Can bus High
      U0100 Lost Communication With ECM
      U0121 Lost Communication With ABS
      U0140 Lost Communication With BCM
      U0141 Lost Communication With LHCM
      U0142 Lost Communication With RHCM
      U0156 Lost Communication With Speedometer
      U1016 Loss of ICM/ECM Serial Data
      U1040 Loss OF Communication With ABS
      U1064 Loss Of TSM/TSSM Serial Data
      U1097 Loss Of Speedometer Serial Data
      U1255 Missing Message at Speedometer EFI
      U1300 Serial Data Low
      U1301 Serial Data Open/High
      U1302 Infotainment Bus Off
      U1306 Infotainment Bus Lost Communication With Handsfree Phone
      U1307 Infotainment Bus Lost Communication With CB
      U1308 Infotainment Bus Lost Communication With Future
      U1312 Infotainment Bus Lost Communication With Future
      U1313 Infotainment Bus Lost Communication With Radio Satellite
      U1314 Infotainment Bus Lost Communication With Navigation
      U1317 Infotainment Bus Lost Communication With High-Out Amplifier

      Harley Radio Diagnostic
      B2006 Radio Switch Stuck or Open
      B2007 Handlebar Switch Shorted High
      B2008 Handlebar Switch Shorted Low
      B2009 Handlebar Switch Stuck or Open
      B2010 Passenger Switch Shorted High
      B2011 Passenger Switch Shorted Low
      B2012 Passenger Switch Stuck or Open
      B2013 Sidecar Switch Shorted High
      B2014 Sidecar Switch Shorted Low
      B2015 Sidecar Switch Stuck or Open
      B2016 Front Speaker Shortened R1.0 Ohm When Setup
      B2017 Front Speaker Opened R>100 Ohms Tested Once per Ignition Cycle Ignition ON after Ignition Off for 10 sec.
      B2018 Front Speaker Shortened to Ground Ignition ON After Ignition OFF for 10 sec.
      B2019 Front Speaker Shortened to Battery Ignition ON After Ignition OFF for 10 sec.
      B2020 Rear Speaker Shortened R1.0 Ohm When Setup
      B2021 Rear Speaker Opened R>100 Ohms Tested Once Per Ignition Cycle Ignition ON After Ignition
      B2022 Rear Speaker Shortened to Ground Ignition ON After Ignition OFF for 10 sec.
      B2023 Rear Speaker Shortened to Battery Ignition ON After Ignition OFF for 10 sec.
      B2024 Sidecar Speaker Shortened R1.0 Ohm
      B2025 Sidecar Speaker Opened R>100 Ohms Tested Once Per Ignition Cycle Ignition ON After Ignition OFF for 10 sec.
      B2026 Sidecar Speaker Shortened to Ground Ignition ON After Ignition OFF for 10 sec.
      B2027 Sidecar Speaker Shortened to Battery Ignition ON After Ignition OFF for 10 sec.

      Sensors and motor

      Sensors and motorHarley-Davidson Fault Code Abbreviations

      Sensors and motor
      ABS – Anti-Lock Braking System
      ACR – Automatic Compression Release
      AFR – Air Fuel Ratio
      AIS – Active Intake Solenoid
      ATS – Air Temperature Sensor
      BAS – Bank Angle Sensor
      BCM – Body Control Module
      CAN – Controller Area Network
      CCM – Cruise Control Module
      CKP – Crank Position Sensor
      DLC – Datalink Connector
      DTC – Diagnostic Trouble Codes
      ECM – Electronic Control Module
      ECT – Engine Coolant Temperature
      ECU – Electronic Control Unit
      EFI – Electronic Fuel Injection
      EFP – Electronic Fuel Pump
      ET – Engine Temperature sensor
      FI – Fuel Injectors
      FPR – Fuel Pressure regulator
      H-DSSS – Harley-Davidson Smart Security System
      HCU – Hydraulic Control Unit, ABS
      [/stag_one_half][stag_one_half_last] HFSM – Hands Free Security Module
      HO2S – Heated Oxygen Sensor
      IAC – Idle Air Control actuator
      IAT – Intake Air Temperature sensor
      ICM – Ignition Control Module
      IMAP – MAP + IAT in one unit
      ISS – Ion Sensing System
      JSS – Jiffy Stand Sensor
      LHCM – Left Hand Control Module
      MAP – Manifold Absolute Pressure Sensor
      MHR – Right Hand Control Module
      RCM – Reverse Control Module
      TCA – Throttle Control Actuator
      TGS – Twist Grip Sensor
      TMAP – Intake Air Temperature / Manifold Absolute Pressure equipment
      TPS – Throttle Position Sensor
      TSM / TSSM – (Turn Signal / Turn Signal Security Module)
      VE – Volume Efficiency
      VIN – Vehicle identification number
      VSS – Vehicle Speed Sensor
      WSS – Wheel Speed Sensor

      These codes should cover the 2017 also.
     
  5. flusher

    flusher Active Member

    357
    38
    50